If the tractor is stuck in the paddy field, it will not only seriously reduce the work efficiency, but also cause damage to the parts. To prevent the tractor from slipping should mainly start from the following aspects: Acid-Base Balance,Calcium Gluconate Injection,Finished Pharmaceutical Product,Acid-Base Balance Agent NOUVASANT PHARMhealth LTD. , http://www.nouvasant.com
1. To understand the depth of the four clay feet, pay special attention to the paddy fields filled with ponds or ditches, and mark them with branches, etc. when necessary.
2. Use anti-skid wheels, high-pattern paddy field wheels or special iron wheels, and pay attention to the installation direction. If the anti-skid wheels are installed, serious mud grabbing, slipping, and sagging will occur.
3. According to the tractor's technical status and the depth of mud, the unit's depth of cultivation and work width can be reasonably adjusted to prevent slippage and subsidence due to overload. When the unit turns, it should raise the tool in time.
4. When plowing, hoeing, and rotaving work, it is necessary to irrigate 3 to 5 centimeters deep in the field. If the water in the field is too little, the drive wheel will stick to mud and cause slipping.
5. When crossing the field ridge, try to use the hoe to plan the rake, so as to prevent the ridge from slipping into the chassis of the tractor. For 30-meter-high fields, we recommend reversing the train to prevent the rear wheels from slipping.
6. If you find that the front wheel is subside, you should stop and retreat immediately, bypass the deep mud feet, and don't risk advancing.
7. When the drive wheel slides on one side, the differential lock can be used to drive the two rear wheels together and drive away from the sag zone. Note that the steering wheel cannot be steered and the differential lock is disengaged immediately after exiting. If there is no differential lock device on the vehicle, a unilateral braking method can be adopted. That is, the brake pedal on the slipping side is slowly depressed, and under the effect of the differential, the non-skid driving wheel is forced to rotate together, thereby enabling the separation pit. .
8. In the event of a car crash, the following points should be noted:
1) Immediately remove farm tools and try to relieve the load.
2) Try to turn the steering wheel or swivel head to the left and right to try to get out of the trap.
3) Do not take the big accelerator to lift the clutch and try to "chongkang pit", otherwise it will sink deeper.
4) Piling for self-rescue. About 5 meters in front of the locomotive hit a wooden stake, and the other end is bolted to the driving wheel, and the gear is cranked to crank the crankshaft so that the tractor can walk and pull the tractor out of the resistance by winding the wire rope around the driving wheel.
5) When the tractor is too deep and it is difficult to get out with the above method, a high-power tractor should be found to pull it out of the pit.